Chemical Burns, Frostbite, Broken Bones — All for Cheap Chicken — There are not fewer injuries, there are fewer injuries being reported

This is a five minute segment of great significance. The discussion focused on the speed of the lines, and the vulnerability of immigrant workers who have signed up for work at slaughter plants.

http://www.npr.org/2016/08/10/489433692/osha-injury-reporting-rule-sheds-light-on-meat-packing-accidents

Thanks for sharing this Joe.

The claim of declining injury rates in this story from the NCC is a lie:

"LOWE: Dan McCausland of the North American Meat Institute acknowledges that the industry is labor-intensive. But he points to safety in ergonomic improvements over the past two decades that have helped decrease injuries significantly."

Injuries haven’t been decreasing; reporting of injuries has been decreasing. In fact, we have actually worked jointly with Tyson on improving their reporting and ergonomics, but unfortunately one of the results has been that because Tyson is more accurately reporting injuries, its injury rate looks like it’s higher than other companies. But that is only because the other companies reporting fewer injuries, and not because they have fewer injuries.

We have been working with another NPR reporter, Laura Santhana, who is also working on a story focusing on the plight of poultry workers. We provided her with a UFCW member to interview to highlight the differences between working in a union vs. a non-union plant. She interviewed our member right before the Democratic National Convention, which delayed the release of the story. So hopefully it will be out soon.

Also, check out this article in The Nation, which reports on OSHA citing Pilgrim’s for systematically denying workers injured on the job access to medical treatment:

Chemical Burns, Frostbite, Broken Bones—All for Cheap Chicken

The workers who put poultry on your table are subject to horrible conditions on the job.

By Michelle ChenTwitter

AUGUST 10, 2016

YOu need to be brave to work in the chicken business—you’re bombarded with bloody carcasses, stung by spurting chemicals, and menaced by gnashing blades that stop for nothing no matter how tired you are, or how much blood is spurting from your hand.

For decades, government regulators have bowed to Big Poultry’s multinational moguls, reluctant to penalize companies for inhumane factory production systems. Recently, however, federal authorities made an unprecedented move for workers’ health by citing the country’s largest poultry producer, Pilgrim’s Pride, for “medical mismanagement,” along with various safety violations. Advocates see the move as a promising step toward fixing an industry that burns through workers’ bodies as fast as it churns meat on the “kill line.”

According to the Occupational Safety and Health Administration (OSHA) citation, which imposed $78,000 in proposed health and safety-related fines on a Pilgrim’s Pride plant in Florida, management systematically failed to refer injured and sick workers to proper outside medical treatment, “which could result in health hazards [like]…prolonged healing, exacerbation of pain, and limited recovery” from injuries on the job.

In February, a worker lacking a proper safety shield reportedly received chemical burns when handling a water chiller, resulting in “a caustic liquid sprayed back in his face.” A lack of facial protection also exposed a workers’ eyes to a “chemical splash” and “zoonotic diseases” during mass bird slaughtering. The management also botched an on-site pollution monitoring test and failed to record 16 work-related injuries or illnesses in 2015.

The advocacy group Oxfam stated that OSHA’s investigation “confirms what Oxfam has heard from poultry workers across the country: workers in poultry plants are subjected to dangerous conditions that are easily preventable.”

Every day, low-wage poultry factory workers risk getting slashed and throttled by machines and burned by chemicals, scrambling to cut and pack up to 140 carcasses per minute. The industry claims it upholds strong safety standards and is improving through technology. But Oxfam’s recent jointinvestigation with Northwest Arkansas Workers Justice Center revealed how another major chicken producer, Tyson, has upgraded Upton Sinclair’sThe Jungle for the neoliberal economy, with brutal pressure to hit hyper-mechanized production quotas, often at the expense of workers’ health.

About half of workers surveyed reported suffering injuries on the job, ranging from lacerations to toxic exposures. Fewer than half said their safety training was adequate; many complained of inadequate safety gear. Just one in 10 had access to paid sick leave. Even unpaid leave was often rationed using “a points system that discourages workers from taking time off.” About six in 10 respondents said they could afford to pay for medical care only “sometimes” or “never,” evidently leaving workers to rely heavily on spotty in-house clinic services.

Debbie Berkowitz, senior fellow for Workplace Safety and Health with the National Employment Law Project and a former OSHA adviser, tells The Nation that the OSHA warned of these problems throughout the industry as early as 20 years ago (and recent Government Accountability Officeresearch affirms this), but companies have failed to systematically reform. The Florida citation, for example, echoes a 2014 investigation of an Alabama plant showing that nurses at the ill-equipped first-aid station forced workers to visit up to 94 times before finally getting referred to a regular physician.

“This is their mode of operation,” Berkowitz says. “If you get hurt at work, you go into the first-aid station, and they just send you back to the job, whether you broke your wrist, whether you have frostbite, whether you have a concussion…they do not let you go to see the doctor.”

The toxic workplace climate deepens the pain. The Arkansas workers described suffering retaliation for reporting health or safety violations, in an impoverished workforce already wracked with anxiety over threats of deportation and frequent wage theft. There were reports of rampant workplace sexual and verbal abuse, and racial and gender discrimination among all groups. Roughly half of workers reported experiencing discrimination, with especially severe rates among Latinos, who, unsurprisingly, also suffer some of the highest rates of injury.

One woman recounted in a testimony, published by Think Progress, that after reporting sexual harassment, she was accused of lying by a female supervisor, “the way she would react towards me, yelling at me, making me feel inferior and intimidated, I didn’t want to file claims with her anymore.”

But while workers fear the boss, the boss isn’t totally fearless. About 90 percent of surveyed workers said that they were “treated differently during OSHA inspection.” The management’s responsiveness suggests that when the law seriously intervenes, the industry does listen, at least temporarily.

[SIGN UP!]

And despite the social barriers, workers do muster the courage to defend their workplace rights. About 40 percent of Arkansas respondents said “they or a coworker have previously spoken up to a supervisor about health and safety issues or other conditions of the workplace.” Despite risk of retaliation, about half the time supervisors were said to be responsive about their grievances. The need for organization, therefore, is critical.

One thing that distinguished the Florida plant and was likely instrumental in triggering federal intervention was the presence of the union, United Food and Commercial Workers—in an industry whereunionization is perilously low.

According to occupational-health specialist Celeste Monforton of George Washington University,

Effective OSHA inspections depend on active involvement of workers. They are, after all, the eyes and ears in a worksite. But without the protection provided by a union, many workers fear talking to an inspector (or are outright told not to).

Ultimately vigilance on many fronts is needed: Unions, regulators, and the consuming public all have a responsibility to hold corporations accountable for the exploitation feeding the meat market. Pointing to market-driven animal welfare campaigns, Jessica Martinez of National Council for Occupational Safety and Health comments via e-mail: “The poultry industry has adopted more humane methods of raising chickens in response to consumer concerns.… We should be equally concerned about the welfare of the workers who bring food to our tables.”

Or as one Arkansas worker explained, “we are not machines, we are human beings, we also have a heart and we want to live.”

When a worksite’s eyes and ears are assaulted with acid burns and degrading abuse, workers need the protection of the law to survive, and the support of a movement to stand up to the boss before the kill line culls another life .

http://www.npr.org/2016/08/10/489433692/osha-injury-reporting-rule-sheds-light-on-meat-packing-accidents

this is a five minute segment of great significance. The discussion focused on the speed of the lines, and the vulnerability of immigrant workers who have signed up for work at slaughter plants.